90 melt-blown fabric melt-blown fabric melt- blown fabric pp

Production line of fully automatic melting and spraying machine

1: polymer feed

This equipment is equipped with automatic vacuum suction feeding device. Generally, the polymer is made into small spherical and granular slices. When the vacuum device is opened, the raw materials can be fed into the hopper equipped with the extruder.in

If the material in the hopper is low, please fill it up immediately. Otherwise, the material will be broken and the melt spray cloth will become thin or not mesh. 

2: molten extrusion

At the feeding end of the screw extruder, the polymer slice shall be mixed with the necessary raw materials such as additives. After mixing, the polymer slice shall enter the screw extruder and be heated to melt. Pay attention to the heating temperature

According to the characteristics of the raw material to be adjusted, can be in accordance with the manufacturer's recommended parameter Settings, can also be adjusted in accordance with the actual production requirements, so that the finished products to meet the use requirements. 

3: fiber formation

The filtered clean melt should pass through the filter screen and then be evenly fed into the spinneret to make the extrusion amount of each spinneret consistent

When the volume, need to stop the machine to check whether there is a fault, check whether the filter screen is blocked, timely troubleshooting problems, so as not to damage the extrusion equipment.When eliminating extruder problems, check

The filter plate of the spinneret can observe whether the holes in the filter plate have impurities that cannot flow normally.The fibers are pulled out of the melt by the crosswind, the spinnerets are squeezed out of the glue, and then cooled.

4: electrostatic electret

After the net through the electrostatic device, so that the melt - spraying non - woven fabric with static electricity.PM2.5 particles and other isolation mainly through two ways: mechanical blocking and electrostatic adsorption.Among them, mechanical block main

It is to use the small pores of the filter material of mask fiber to block the invasion of bacteria and viruses, but this mechanical blocking effect is very bad for the filtration effect of particles with particle size less than 1 m, so it cannot work

To urification.Therefore, in order to improve the filtration efficiency of the mask, the electrostatic adsorption capacity of the mask can be increased.And increase the capacity of mask electrostatic adsorption, the need to melt spray non - spinning

Cloth filter material for electret treatment.After electret treatment, the surface of the fiber will be charged with a large amount of static electricity 

Add breathing resistance.

6: slitting and winding

There is rewinding equipment at the end of the production line.The fusion-sprayed non-woven fabric is cut and rolled up to the size required for packaging.Winding has tension control device, so that the winding material is always stable

Volume status.Before the rewinding is equipped with a cutting knife, which can remove the edge material, so that the packaging specifications for packaging, of course, can also be cut into the size of the product production, the distance between the cutting knife is non-woven

The width of the finished product, this distance can be adjusted, according to the production needs to adjust and arrange the number of cutting knives

Company

Contact Us

Dongguan Huanlian Automation Equipment Co., Ltd.

• *Email
  Please enter Your valid email address.
• *To

  

  Dongguan Huanlian Automation Equipment Co., Ltd.
• *Message
  Your inquiry content must be between 20 to 5000 characters.
•  

  Please enter a correct verification code.

Send Now

Product Categories

Apparel Folding Packing Machine	Customized Labeler	Filling Line	food packaging machinery
Mask Machine	Mask mechanical parts	N95 mask machine	N95 sponge sticking machine
Production Line	Spare Parts	Standard Labeler	straws machine
Ungrouped

More

New Products

• intermediate melt-blown non-woven fabric melt-blown non-woven fabric brazil melt-blown non-woven fabric raw material
• melt-blown nonwoven fabric cutting machine filtert-blown fabric non-wonen fabric
• medical filter melt-blown fabric melt-blown fabric in turkey bfe99 melt-blown nonwoven fabric
• electrostatic melt-blown fabric melt-blown fabric mould melt blown none-woven fabrics
• melt-blown fabric 99 fabric heater fabric mold
• pp melt blown non-woven fabric production line melt-blown melt blown fabric melt-blown non-woven nonwoven fabric making machine

• pp granules melt-blown fabric mask melt-blown fabric making machine melt-blown nonwoven fabric making machine
• 10/20m melt-blown nonwoven waterproof fabric fabric production line polypropylene nonwoven fabric
• melt-blown fabric shantou fabric making machine heater for melt-blown fabric
• melt-blown non-woven fabric fabric n95 air filter fabric cutting machine
• melt-blown nonwoven fabric melt blown non-woven fabric melt-blown fabric machine
• melt blown fabric nonwoven machine melt blown pp fabric machine melt blown fabric production machine

• pp melt blown spun bond non woven fabric machine king machine melt-blown fabric machine melt blown fabric
• melt blown fabric for mask machine 600mm melt blown nonwoven fabric machine pp melt-blown nonwoven fabric making machine
• melt-blown fabric rewinding machine pp melt blown nonwoven fabric machine melt blown fabric manufacturing machine
• pp melt blown spunbond nonwoven fabric machine pp melt blown non woven fabric making machine melt blown fabric machine nonwoven
• bfe99 melt blown nonwoven fabric machine machine to manufacture melt blown fabric melt blown nonwoven fabric machine ruain
• pp melt blown fabric making machine melt blown non woven fabric making machine melt blown non woven fabric machine

• mask melt blown fabric filter making machine melt blown machine fabric mask melt blown fabric making machine
• melt blown fabric making machine melt-blown fabric machine melt blown nonwoven fabric making machine
• melt blown nonwoven fabric machine melt blown fabric machine pp melt blown nonwoven fabric machine
• automatic mask making machine n95 mask making machine fish medical surgical mask making machines
• n95 anti pollution mask making machine 1- n95 face mask body making machine mask making manual machine
• n95 face mask making machine fully automatic medical face mask machine mask manufacturing machine

Popular Searches

• textile equipment
• face mask making machine
• cover making machine
• delinter
• fabric recycling machine
• cotton opener machine pp fiber
• carding machine
• felting machinery
• mattress production line
• polyester staple fiber line
• bonding wadding machine
• polyester wadding production line
• nonwoven machine
• needle punching machine
• nonwoven carding machine
• coconut fiber
• nonwoven fabric making machine
• jute fiber
• tearing machine
• spare parts machine
• quilt machine
• fiber opening machine
• cloth line
• mask making machine
• cover machine
• disposable shoe cover machine
• shoe cover making machine
• nonwoven machinery
• nonwoven production line
• nonwoven fabric machine

Recommended Products

• Baby Diaper Making Machine full Automatic Baby Diaper Machine For I shape baby Diaper with packaging machine
• Full servo Adult diaper production Line, Adult diaper making machine automatic, Adult diaper machine with packing machine
• T Shape Full Servo Automatic Baby Diaper Machine
• Full Servo Automatic Wet Wipe Machine
• Full Automatic Menstrual Pants Production Line Disposal Menstrual Pad Making Machine from Fujian
• Welldone Hot Sale T Shape Full Servo Automatic Baby Diaper Machine
• Customized Manufacture Full Servo Two Pieces Pull Up Machine
• Automatic Sanitary Napkin Machine Woman Sanitary Napkins Lady Pad Making Machine
• Welldone Hot Sale T Shape Full Servo Automatic Baby Diaper Machine
• Hygiene Equipment Elder Nursing Care Pad Underpad Manufacturing Machine
• Full Servo Automatic pull up Adult Diapers making machine For Manufacturing adult diaper pants production line
• Semi Servo Disposal Baby Diaper Making Machine Prix In China

More

Find Similar Products By Category

Manufacturing & Processing Machinery > Textile Machinery & Parts > Nonwoven Machine