Vertical dryer FUYU manufacture

Vertical dryer

1. 1.     Productintroduction：

Verticaldrying machine is facing the now ubiquitous briquette drying furnace largeamount of investment, covers an area of large area, the failure rate high case,for industrial briquette drying characteristics, the use of low wind andgravity principle, the R & D design and industrial test, the productreplacement upgrade, put into operation and the large scale of several stages,which lasted several years and get the success of the product. In the product,fully embodies the application of innovation, development efficiency, reducecosts, improve quality. Vertical dryer production safety and protect theenvironment, is the ideal equipment of briquette production line for drying.

1. 2.     Workingprinciple：

Afterforming the "water polo" conveyed by belt conveyor to the top by thedistributing device evenly distributed to the top section. The briquette in itsorbit while slowly moving by gravity side heat exchange with the wind. Coalmoisture evaporated by strong winds was taken away. The briquette evaporationprocess about two hours to fully dry. Economic characteristics: compared withthe general purpose of the present, the amount of investment is reduced by 1/2,the area is 1/5-1/3, and the energy consumption and operation cost are greatlyreduced. Use features: This product is a good match, easy to connect with otherdevices in the production line and realize automation. Convenient operation andmaintenance. No mechanical moving parts of the drying furnace body, no need tomaintain the daily. Continuous operation, high efficiency, large output. To alarge chemical fertilizer plant use, dry coal rods, achieved good results: intothe gas furnace coal rods, the water will be around 3% of the gas production issignificantly improved; a large number of savings venues, expanding production.

1. 3.     Mainapplication：

Powdercoal after forming machine to suppress the formation, the water is usually inthe 12-14%. After drying, the moisture content is reduced to 2-4%, which canmeet the strength and storage requirements. On the basis of this, the water canbe reduced to less than 1.5%, and can also be used to dry mass of coal, coaland so on.